07927 860502

Ford Focus EGR delete in Stoke‑on‑Trent

The EGR valve feeds exhaust gas back into the intake, and on a diesel Ford Focus it can clog with soot and stick. We hold 24 diesel Focus engines: pick yours below for the price and what a remap adds.

EGR work on a diesel Ford Focus is £249, or £349 with a Stage 1 remap at the same time, at our unit in Fenton, Stoke-on-Trent. We hold 24 diesel Focus engines. Pick yours below for the price and what a remap adds, then message us with your reg.

Ford Focus

Find your engine

Generation

The 1.5 EcoBlue 95hp is a diesel with exhaust gas recirculation (EGR).

EGR delete from £249

Stage 1 on this engine: typically 120 to 125bhp from 94bhp stock

Message us about this engine

What an EGR delete is

Exhaust gas recirculation sends part of the exhaust back into the Focus intake to cut emissions. Over time the soot builds up in the valve, the cooler and the inlet. An EGR delete recalibrates the engine software so the system is switched off and the engine breathes clean air only.

Why Focus owners ask for it

  • No more sticking or clogged EGR valve faults
  • Less soot carried into the intake and inlet manifold
  • No EGR warning lights or limp mode from a failed valve
  • Often done with a DPF delete or a Stage 1 remap

How it works

  1. Diagnose

    We read the fault codes and live data first, so we know the state of the system and anything else that needs attention.

  2. Read the ECU

    We read the engine software, over the diagnostic port where the car allows it and with the ECU out on the bench where it does not.

  3. Calibrate

    The software is calibrated for your engine so it runs properly without the system, with no warning lights.

  4. Check and hand back

    We clear the codes, run full diagnostics again and check the car before it goes back to you.

Pair it with a remap

Most owners pair it with a Stage 1 remap in the same visit. The 2.0 TDCi 163hp typically goes from 161bhp to around 190 to 205bhp at Stage 1, and Stage 1 plus EGR delete is £349.

Typical gains for every Focus engine

Other emissions services for the Focus

Other Ford models

Ford Focus EGR FAQ

Focus EGR questions

£249, or £349 with a Stage 1 remap at the same time.

It feeds exhaust gas back into the intake, so on a diesel Focus it can clog with soot and stick.

All 24 diesel Focus engines we hold. Pick yours on this page for the price and what a remap adds.

Still have a question? Message us with your reg and what you would like done.

07927 860502