07927 860502

Renault Kadjar EGR delete in Stoke‑on‑Trent

The EGR valve feeds exhaust gas back into the intake, and on a diesel Renault Kadjar it can clog with soot and stick. We hold 5 diesel Kadjar engines: pick yours below for the price and what a remap adds.

EGR work on a diesel Renault Kadjar is £249, or £349 with a Stage 1 remap at the same time, at our unit in Fenton, Stoke-on-Trent. We hold 5 diesel Kadjar engines. Pick yours below for the price and what a remap adds, then message us with your reg.

Renault Kadjar

Find your engine

Generation

The 1.5 Diesel 110hp is a diesel with exhaust gas recirculation (EGR).

EGR delete from £249

Stage 1 on this engine: typically 135 to 140bhp from 108bhp stock

Message us about this engine

What an EGR delete is

Exhaust gas recirculation sends part of the exhaust back into the Kadjar intake to cut emissions. Over time the soot builds up in the valve, the cooler and the inlet. An EGR delete recalibrates the engine software so the system is switched off and the engine breathes clean air only.

Why Kadjar owners ask for it

  • No more sticking or clogged EGR valve faults
  • Less soot carried into the intake and inlet manifold
  • No EGR warning lights or limp mode from a failed valve
  • Often done with a DPF delete or a Stage 1 remap

How it works

  1. Diagnose

    We read the fault codes and live data first, so we know the state of the system and anything else that needs attention.

  2. Read the ECU

    We read the engine software, over the diagnostic port where the car allows it and with the ECU out on the bench where it does not.

  3. Calibrate

    The software is calibrated for your engine so it runs properly without the system, with no warning lights.

  4. Check and hand back

    We clear the codes, run full diagnostics again and check the car before it goes back to you.

Pair it with a remap

Most owners pair it with a Stage 1 remap in the same visit. The 1.7 dCi 150hp typically goes from 148bhp to around 175 to 190bhp at Stage 1, and Stage 1 plus EGR delete is £349.

Typical gains for every Kadjar engine

Other emissions services for the Kadjar

Other Renault models

Renault Kadjar EGR FAQ

Kadjar EGR questions

£249, or £349 with a Stage 1 remap at the same time.

It feeds exhaust gas back into the intake, so on a diesel Kadjar it can clog with soot and stick.

All 5 diesel Kadjar engines we hold. Pick yours on this page for the price and what a remap adds.

Still have a question? Message us with your reg and what you would like done.

07927 860502