07927 860502

Volkswagen Passat EGR delete in Stoke‑on‑Trent

The EGR valve feeds exhaust gas back into the intake, and on a diesel Volkswagen Passat it can clog with soot and stick. We hold 22 diesel Passat engines: pick yours below for the price and what a remap adds.

EGR work on a diesel Volkswagen Passat is £249, or £349 with a Stage 1 remap at the same time, at our unit in Fenton, Stoke-on-Trent. We hold 22 diesel Passat engines. Pick yours below for the price and what a remap adds, then message us with your reg.

Volkswagen Passat

Find your engine

Generation

The 2.0 TDI 122hp is a diesel with exhaust gas recirculation (EGR).

EGR delete from £249

Stage 1 on this engine: typically 145 to 155bhp from 120bhp stock

Message us about this engine

What an EGR delete is

Exhaust gas recirculation sends part of the exhaust back into the Passat intake to cut emissions. Over time the soot builds up in the valve, the cooler and the inlet. An EGR delete recalibrates the engine software so the system is switched off and the engine breathes clean air only.

Why Passat owners ask for it

  • No more sticking or clogged EGR valve faults
  • Less soot carried into the intake and inlet manifold
  • No EGR warning lights or limp mode from a failed valve
  • Often done with a DPF delete or a Stage 1 remap

How it works

  1. Diagnose

    We read the fault codes and live data first, so we know the state of the system and anything else that needs attention.

  2. Read the ECU

    We read the engine software, over the diagnostic port where the car allows it and with the ECU out on the bench where it does not.

  3. Calibrate

    The software is calibrated for your engine so it runs properly without the system, with no warning lights.

  4. Check and hand back

    We clear the codes, run full diagnostics again and check the car before it goes back to you.

Pair it with a remap

Most owners pair it with a Stage 1 remap in the same visit. The 2.0 BiTDI 240hp typically goes from 237bhp to around 270 to 290bhp at Stage 1, and Stage 1 plus EGR delete is £349.

Typical gains for every Passat engine

Other emissions services for the Passat

Other Volkswagen models

Volkswagen Passat EGR FAQ

Passat EGR questions

£249, or £349 with a Stage 1 remap at the same time.

It feeds exhaust gas back into the intake, so on a diesel Passat it can clog with soot and stick.

All 22 diesel Passat engines we hold. Pick yours on this page for the price and what a remap adds.

Still have a question? Message us with your reg and what you would like done.

07927 860502